Engine And Engine Cooling › Engine › Diesel Vehicle Recalls

Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2025 Volvo VN and 2025 New VN trucks. The idler gear bracket fasteners may have been improperly tightened, allowing the idler gear to detach from the engine.

Chrysler (FCA US LLC) is recalling certain 2014-2018 Ram 1500 and 2014-2016 Jeep Grand Cherokee vehicles equipped with 3.0L diesel engines. The crankshaft position sensor tone wheel may delaminate causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.

Volvo Trucks North America (Volvo) is recalling certain 2016-2019 Volvo VNL trucks equipped with Cummins ISX15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.

Chrysler (FCA US LLC) is recalling certain 2013-2017 RAM 2500, 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles, equipped with Cummins 6.7L Turbo Diesel engines that have Concentric-brand water pumps without a vent hole. These water pumps may leak coolant.

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Passat vehicles, equipped with diesel engines and Direct-Shift Transmissions (DSG). The vehicle's underbody heat shield may not be long enough to protect the right half-shaft grease boot from heat, potentially resulting in a grease leak.

Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2014 Ram 2500, 3500, 4500, and 5500 trucks manufactured March 27, 2009, to September 5, 2013. In the affected vehicles, the electrical connectors of the diesel fuel heater may overheat.

CHRYSLER IS RECALLING 108,429 MY 2007-2008 DODGE RAM 2500 AND 3500 PICKUP TRUCKS EQUIPPED WITH 6.7L DIESEL ENGINES. A SILENCER PAD CAN SAG AND CONTACT THE EXHAUST GAS RECIRCULATION (EGR) COOLER.

FORD IS RECALLING 2,811 MY 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH C7 OR C9 CATERPILLAR DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.

ON CERTAIN TRUCKS, AN INCORRECT SOFTWARE PARAMETER WAS LOADED WHICH RESULTED IN THE DIESEL PARTICULATE FILTER (DPF) 'INHIBIT' FUNCTION BEING DISABLED. THE 'INHIBIT' FUNCTION IS A MEANS FOR THE DRIVER TO STOP A DPF REGENERATION FROM OCCURRING IF A VEHICLE IS IN A LOCATION THAT MAY PRESENT A HAZARDOUS SITUATION.

ON CERTAIN UTILITY VANS, THE CRANKSHAFT SENSOR IN CERTAIN DIESEL ENGINES COULD FAIL DUE TO SEPARATION OF BOND WIRES FROM THE LEAD FRAME IN THE SENSOR. THIS RESULTS IN AN INTERRUPTION IN THE ELECTRICAL CONNECTION IN THE CHIP HOUSING OF THE SENSOR.

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR C7 OR C9 DIESEL ENGINES, A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND MAY CAUSE THE TURBOCHARGER TO FAIL AND CAUSE LOSS OF THROTTLE CONTROL WITH WARNING.

ON CERTAIN LOW CAB FORWARD CHASSIS TRUCKS, THE UNSEALED INJECTION PRESSURE REGULATOR CONNECTOR IS EXPOSED TO THE OUTSIDE ENVIRONMENT DUE TO ITS LOCATION ON THE BACK OF THE ENGINE AND THE ENGINE'S LOCATION IN THE VEHICLE. THE CONNECTOR HAS A HEAT INSULATION SLEEVE THAT MAY RETAIN WATER AROUND THE CONNECTOR.

ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS WESTPORT B GAS PLUS OR C GAS PLUS 6 CYLINDER ENGINES, THE ELECTRONIC CONTROL MODULE CALIBRATION MAY NOT CORRECTLY DETECT A THROTTLE PLATE ACTUATOR FAILURE THAT COULD RESULT IN AN UNCOMMANDED OPEN THROTTLE CONDITION.