Vehicle Speed Control Vehicle Recalls

Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2024 VN vehicles. The engine may not return to idle within 2 seconds if the accelerator pedal position sensor becomes disconnected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 124, "Accelerator Control Systems."

Nissan North America, Inc. (Nissan) is recalling certain 2018-2023 LEAF vehicles. The vehicle may accelerate unintentionally if the driving mode is changed ("D" to "B"; e-Pedal "On"; or "ECO" mode) after disengaging the cruise control.

BMW of North America, LLC (BMW) is recalling certain model year 2012 K1600 GT and K1600 GTL motorcycles. In certain riding conditions, an incorrect throttle valve control signal may be received by the engine control unit, limiting the engine speed.

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ALL WHEEL DRIVE AND A 3.6L V6 ENGINE, THE TORQUE MONITORING FUNCTIONS OF THE ELECTRONIC THROTTLE CONTROL (ETC) ARE NOT ENABLED. THESE FUNCTIONS CAN LIMIT ENGINE SPEED AND TORQUE IF UNUSUAL ENGINE CONTROL MODULE (ECM) HARDWARE OR SOFTWARE FAILURES OCCUR.

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

ON CERTAIN MOTORCYCLES, SOME DIGITAL SPEEDOMETERS MAY EXPERIENCE A COMPUTER PROGRAM ERROR, CAUSING THE SPEEDOMETER TO INDICATE APPROXIMATELY 25 PERCENT LESS THAN THE ACTUAL VEHICLE SPEED.

CERTAIN PICKUP TRUCKS, EQUIPPED WITH CUMMINS DIESEL ENGINES AND MANUAL TRANSMISSIONS, MAY EXPERIENCE AN ELEVATED IDLE SPEED AFTER EXTENDED CRUISE CONTROL USE.

ON CERTAIN SPORT UTILITY VEHICLES, DURING EXTREMELY LOW TEMPERATURE CONDITIONS, ICE CAN BUILD UP INSIDE THE ENGINE THROTTLE VALVE. THIS ICE BUILD-UP COULD CAUSE THE ACCELERATOR PEDAL TO STICK OR NOT TO RETURN TO IDLE AFTER ACCELERATING.

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH A SUPERCHARGER, UNDER CERTAIN CONDITIONS, SUCH AS FULL THROTTLE IN LOW GEAR WHEN THE ENGINE IS NOT FULLY WARMED UP AND AT COLD AMBIENT TEMPERATURE, THE AMOUNT OF INTAKE AIR FLOW THROUGH THE AIR FLOW METER MAY EXCEED THE MAXIMUM PRESET DIAGNOSIS LIMIT VALUE.

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AN ELECTRONIC THROTTLE CONTROL SYSTEM, THE STOPPER FOR THE ACCELERATOR PEDAL WILL PREVENT EXCESSIVE MOVEMENT OF THE ACCELERATOR POSITION SENSOR. IF THE DRIVER APPLIES OVERLY EXCESSIVE FORCE TO THE ACCELERATOR PEDAL WHILE AT THE SAME TIME PUSHING IT TO THE RIGHT, THE PEDAL CAN "OVER TRAVEL" DUE TO THE DESIGN OF THE PEDAL STOPPER.

ON SOME SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE COULD HAVE BECOME KINKED DURING VEHICLE ASSEMBLY, RESULTING IN CHAFFING OF THE CABLE. CONTINUED CHAFFING CAN LEAD TO BREAKAGE OF THE INTERIOR CABLE STRANDS.

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.5 LITER OR 1.6 LITER ENGINES THAT WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, MAINE, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WHILE DRIVING AT A STEADY THROTTLE OPENING FOR AN EXTENDED PERIOD OF TIME DURING EXTREMELY COLD AMBIENT TEMPERATURES (BELOW APPROXIMATELY -5 DEGREES FAHRENHEIT WITH HIGH HUMIDITY), MOISTURE IN THE COMBUSTION CHAMBER BLOWBY GASES CAN FREEZE AND BLOCK THE POSITIVE CRANKCASE VENTILATION (PCV) VALVE AND HOSE. IF THE PCV HOSE FREEZES, COMBUSTION CHAMBER GASES ARE FORCED THROUGH THE BREATHER HOSE INTO THE AIR INTAKE HOSE AND THEN INTO THE THROTTLE BODY.

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL AND V6 ENGINES, AND BUILT AT ONE OF TWO LINES AT THE KENTUCKY PLANT. THE ACCELERATOR CABLE HOUSING COULD BE DEFORMED AT THE CRUISE CONTROL ACTUATOR-TO-THROTTLE BODY CONNECTION. THE ACCELERATOR INNER-CABLE COULD WEAR AWAY AND EVENTUALLY BREAK.

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE CAN HAVE A CRACKED OR MISSING SPEED CONTROL CABLE SERVO CAP LOCATING TAB. THE LOCATING TAB COULD ENTER THE SERVO CLUTCH CAVITY AND INTERFERE WITH THE SPEED CONTROL SERVO CLUTCH. ALSO, WATER COULD ENTER THOSE UNITS THAT CONTAIN A CRACKED OR MISSING SERVO CAP LOCATING TAB, EVENTUALLY CAUSING CORROSION THAT COULD INTERFERE WITH THE FUNCTION OF THE SPEED CONTROL.

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE CAN HAVE A CRACKED OR MISSING SPEED CONTROL CABLE SERVO CAP LOCATING TAB. THE LOCATING TAB COULD ENTER THE SERVO CLUTCH CAVITY AND INTERFERE WITH THE SPEED CONTROL SERVO CLUTCH. ALSO, WATER COULD ENTER THOSE UNITS THAT CONTAIN A CRACKED OR MISSING SERVO CAP LOCATING TAB, EVENTUALLY CAUSING CORROSION THAT COULD INTERFERE WITH THE FUNCTION OF THE SPEED CONTROL.

VEHICLE DESCRIPTION: PASSENGER CARS. VAPORS FROM THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM CAN CONDENSE AND FREEZE INSIDE OF THE THROTTLE BODY WHEN THE VEHICLE IS OPERATED IN EXTREMELY COLD AMBIENT TEMPERATURES.

VEHICLE DESCRIPTION: LIMOUSINES. DURING NORMAL ENGINE ROLL, THE PLASTIC END FITTING OF THE CRUISE CONTROL CABLE COULD CONTACT THE BRAKE MASTER CYLINDER AND FRACTURE. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS."

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.

VEHICLE DESCRIPTION: SUPER DUTY TRUCKS AND CHASSIS-CABS EQUIPPED WITH 5.4L MANUAL TRANSMISSION POWERTRAINS. THE ACCELERATOR CABLE CORE WIRE CAN WEAR THE CABLE CONDUIT END FITTING DUE TO A FIFTEEN DEGREE ANGLE IT MAKES WITH THE CONDUIT AT THE THROTTLE BODY END. THIS COULD ALSO LEAD TO WEAR OR SEPARATION OF STRANDS OF THE CORE WIRE, WHICH COULD PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.