2019 Chevrolet 5500HD

4 Recalls · 100 Complaints · 0 Crashes · 2 Fires

Moderate

4

Recalls

100

Complaints

2

Fires

No crashes reported

The 2019 Chevrolet 5500HD has 4 recalls and 100 owner complaints filed with NHTSA. No crashes have been reported. 2 fires have been reported. The most common issue involves suspension:rear:springs:leaf spring assembly:u-bolt, leaf spring to axle.

Recalls (4)

SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE
Mar 19, 2021

Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2015-2017 Isuzu NPR, Reach, 2016-2020 Isuzu NPR XD, NPR HD, NQR, 2016-2021 Isuzu NRR, 2017-2020 Chevrolet 4500XD, 4500HD, 5500HD, and 2020 Chevrolet 5500XD vehicles. The U-bolt nuts for the rear axle may not have been properly ...

Consequence

The misalignment may cause the propeller shaft to separate, causing a loss of power to the rear wheels and a stall, increasing the risk of a crash.

Remedy

Isuzu will notify owners, and dealers will inspect and, if needed, replace and tighten the rear axle U-bolt nuts, free of charge. The recall began on April 23, 2021. Owners may contact Isuzu cust...

WHEELS:LUGS/NUTS/BOLTS/STUDS
Nov 20, 2019

Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2017-2020 NPR-HD, 2019-2020 NPR-XD, NQR, NRR, Chevrolet 4500HD, Chevrolet 5500HD and Chevrolet 5500XD, and 2020 Chevrolet 4500XD vehicles. The lug nuts on the rear outer wheels may not have been properly tightened when installe...

Consequence

If the lug nuts were not properly tightened, they can loosen, causing the to wheel separate from the vehicle, increasing the risk of a crash.

Remedy

Isuzu will notify owners, and dealers will inspect the rear outer wheel lug nuts and tightening or replacing them as necessary, free of charge. The recall began December 20, 2019. Owners may cont...

ELECTRICAL SYSTEM:SOFTWARE
May 29, 2020

General Motors is recalling certain 2019-2020 Chevrolet 4500HD, 5500HD, and 6500HD Medium Duty trucks. If the vehicle's body control module (BCM) loses communication with the vehicle's electronic brake control module (EBCM), the EBCM software programming may not illuminate the vehicle's ABS malf...

Consequence

If a driver is unaware that the ABS system is malfunctioning, there may be an increased risk of a crash.

Remedy

GM will notify owners, and dealers will update the software calibration for the body control module (BCM). The recall began June 29, 2020. Owners may contact Chevrolet customer service at 1-800-2...

PARK OUTSIDE — Fire risk, do not park in a garage
SERVICE BRAKES, HYDRAULIC
Apr 13, 2023

General Motors. LLC (GM) is recalling certain 2019-2023 Chevrolet 4500HD, 5500HD, and 6500HD Medium-Duty trucks. The brake pressure sensor assembly may leak brake fluid into the brake pressure switch and cause an electrical short-circuit.

Consequence

An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.

Remedy

Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the master cylinder pressure sensor and inspect the wire harness, replacing it...

Owner Complaints (100)

Jan 2, 2026
MN

BOTH front door actuators have failed. Can NOT open the front passenger side door at ALL and the front driver side door will ONLY OPEN from the INSIDE. My passenger had to exit the vehicle through the front passenger side window when the door malfunctioned in January. Then about 2 weeks later we could no longer open the front driver's side door from the outside. The vehicle is available for inspection upon request. My front seat passenger was trapped in the car. Luckily the window was able to roll down and my passenger was limber enough to crawl out through the window.

Dec 14, 2024
TX

Over a year ago, my vehicles engine began ticking. On 12/14/2024, while driving the vehicle, it developed a rod knock, went into a limp mode and was towed back to our house. I eventually took the vehicle to Honda in Beaumont, Tx where they did an inspection of the vehicle and verbally told me it was the crankshaft, but would not provide me any documentation stating that. According to the lady at the desk, the service tech had never seen or heard of an issue like this in these vans. I was quoted almost $10,000 to replace the engine with a salvage yard engine with almost as many miles on it. I knew prior to taking it to Honda that there was a recall that did not cover my vehicle regarding this same issue. The vehicle is still parked at my house being started occasionally to keep battery charged.

Feb 18, 2026
OH

I was sold this 2024 Mazda cx30 from Ken ganley kia located in mentor Ohio (44060) the vehicle started showing major electrical issues. when they occur I have no control of the functions of anything in the cabin (infotainment, heat/air, braking system,) just to name a few. My wife and I were assured we were purchasing a good safe and reliable used vehicle. I feel this vehicle is extremely unsafe and unpredictable and ken ganley kia of mentor refuse to take this unsafe vehicle back or even pay for the repairs. I am utterly disappointed such a big name in the auto industry could turn there back on a customer not only that let a young family pull off in a unpredictable electrical nightmare of a vehicle and refuse to stand by it.

Jan 12, 2026
CA

While driving through west Los Angeles, the vehicle suddenly began emitting white smoke from the engine compartment. There were no prior warning lights, messages, or symptoms indicating a problem. The smoke quickly intensified and turned dark. Thick smoke filled the air, and the cockpit, with the smell of toxic fumes. I safely maneuvered to the shoulder and exited the vehicle with my passenger. Flames erupted from the front of the vehicle. We called 911, which dispatched the fire department. The LAFD responded, cutting open the hood in order to extinguish the fire. The vehicle was towed to a yard following the incident. The vehicle and its contents were declared a total loss.   BWM North America dispatched a technician to inspect the vehicle. After inspection, the manufacturer indicated that the starter was the source of the fire. At the time of the incident, the vehicle was subject to a safety recall related to the starter with no remedy available. The failure occurred without warning. Both occupants were exposed to heavy smoke.

Fire
Feb 27, 2026
TN

we've had to replace the engine. Twice and the electric power steering quit, working completely.And now they want five thousand dollars to replace it.When it's a known problem.

Other Model Years

Related Models

Helpful Guides

Source: NHTSA (National Highway Traffic Safety Administration). Data reflects all recalls and owner complaints on file.