Skip to main content
MyRecallCheckNHTSA recall explorer

NHTSA model-year recall report

2002 GMC Envoy Xl Recalls

3 campaigns in our verified NHTSA snapshot, with source consequences, remedies, and VIN-specific next steps.

Check exact VIN status Decode a VIN

3

NHTSA campaigns

3

Affected systems

0

Urgent advisories

Oct 27, 2005

Latest campaign date

At a glance

What the record says

This model year's count is equal to the GMC Envoy Xl average of 3.0 campaigns per listed year. That is context only—not proof that this year is safer or less safe.

The most frequent affected category is Latches / Locks / Linkages › Doors › Latch, appearing in 1 campaign.

  1. 1

    Read

    Review every campaign and urgent instruction below.

  2. 2

    Verify

    Check your exact VIN with NHTSA or the manufacturer.

  3. 3

    Repair

    Contact an authorized dealer if a campaign applies.

Source campaign records

All 2002 GMC Envoy Xl recall campaigns

Shown newest first. NHTSA summary, consequence, and remedy text is preserved without truncation.

NHTSA campaign 05V494000

Latches / Locks / Linkages › Doors › Latch

Manufacturer: GENERAL MOTORS CORP.

Reported Oct 27, 2005

What is recalled

CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA.

Safety consequence

IF THE DOOR IS NOT LATCHED PROPERLY AND IT GOES UNNOTICED, IT MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN UNBELTED OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.

Manufacturer remedy

DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.

Campaign history does not confirm applicability or repair status for one VIN.

Campaign details

NHTSA campaign 04V527000

Exterior Lighting › Brake Lights

Manufacturer: GENERAL MOTORS CORP.

Reported Nov 1, 2004

What is recalled

ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.

Safety consequence

AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.

Campaign history does not confirm applicability or repair status for one VIN.

Campaign details

NHTSA campaign 04V046000

Visibility › Windshield Wiper / Washer

Manufacturer: GENERAL MOTORS CORP.

Reported Feb 4, 2004

What is recalled

CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.

Safety consequence

DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.

Campaign history does not confirm applicability or repair status for one VIN.

Campaign details

Other GMC Envoy Xl model years

Compare campaign histories within the same model. Counts are descriptive, not a safety grade.

20065 campaigns20041 campaign20033 campaigns20023 campaigns
View all model years

Other 2002 GMC recall reports

2002 GMC Envoy14 campaigns2002 GMC Sierra7 campaigns2002 GMC Yukon5 campaigns2002 GMC Safari3 campaigns2002 GMC Yukon Xl2 campaigns2002 GMC Denali1 campaign

2002 GMC Envoy Xl recall questions

How many recalls does the 2002 GMC Envoy Xl have?

This verified dataset contains 3 NHTSA campaigns associated with the 2002 GMC Envoy Xl. A campaign can apply to some, not all, vehicles of the same model year.

Does this confirm an open recall for my 2002 GMC Envoy Xl?

No. This page is a model-year campaign history. Use NHTSA's official lookup or an authorized dealer to confirm whether a campaign applies to your exact VIN and whether the repair remains open.

Are vehicle recall repairs free?

When a safety recall campaign applies to your VIN, the manufacturer remedy is generally provided at no charge through an authorized dealer. Confirm eligibility and scheduling with the manufacturer or dealer.

Source: NHTSA. Dataset includes campaigns through Jul 30, 2026. Last processed Aug 8, 2026. Methodology